View AN2001_361934.PDF datasheet online --- IC-ON-LINE

Datasheet File OCR Text:

Freescale Semiconductor, Inc.
MOTOROLA
Order this document by: AN2001/D
SEMICONDUCTOR
APPLICATION NOTE
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES200
by Randy Dees Rev. 1, 31 July 2001
1 Introduction
Freescale Semiconductor, Inc...
The Motorola MPC555EVB/ETAS ES200 evaluation board was designed with multiple interfaces to allow flexibility for expansion. There are three sets of connectors for expansion. The MAPI-400+100 is on the bottom side of the board and has access to all signals required to interface to a user application board. The host communication expansion (HCE) connectors allow access to the bus of the MPC555. The customized communication expansion (CCE) allows access to some of the MPC555 on-chip communication ports. The HCE and the CCE are on the top side of the EVB555.
2 The Host Communication Expansion Connector (HCE)
The host communication expansion connectors on the EVB555 are designed for use as an expansion of the external bus of the MPC555. They could be used to add additional memory or additional peripherals. There are two 60-pin connectors (CO106 - A and CO107 - B) part number Samtec TFM-130-12S-D-P. The matching connector required on the expansion board is SFM-130-02-S-D-P. The pin-out of the HCE is shown in Table 1. The two connectors are mounted on 1.8 inch (45.72 mm) centers. This allows for a board of approximately three square inches. NOTE An ETAS ETK interface may be mounted above the HCE board. The total height (including the connectors on the EVB555 and all components on the HCE board) must be below 0.6875 inches to allow clearance of the ETK board. 2.1 Memory Chips On The HCE All 32 bits of the MPC555 data bus are available on the HCE connectors. Memory boards designed for these connectors should use all 32 bits for the best performance. On a full-featured board, utilizing memories less than 32 bits wide, the memory can be implemented with multiple chips. For 16-bit wide memories, two chips should be used. Provisions should be made on the expansion board to allow the second memory to be disabled to allow for smaller bus widths on the EVB555. 16-bit only memories should be connected to D0-D15 of the data bus. CS[2] is available for use on the HCE board. If nonvolatile memories are used, CS[0] could also be used to allow for booting from the external memory. (It is not possible to boot from the Texas Instruments TMS28F033 on the EVB555.) If CS[0] is used, the TMS28F033 can be disabled by using the SGF_SEL signal on pin 160 of the ETK connector (CO508). A logic high (default) enables the EVB555 on-board external flash memory. In addition, CSHCE could be used if the chip timing is the same as used by the memory on the EVB555 and can fit in a 1-Mbyte memory size.
This document contains information on a new product. Specifications and information herein are subject to change without notice.
(c) MOTOROLA INC., 2001
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
2.2 Peripherals On The HCE Peripherals can also be added on to the HCE bus. Chip selects CS[2] and CS[3] are available on the HCE connectors. In addition, CSHCE could be used if the chip timing is the same as used by the memory on the EVB555 and can fit in a 1-Mbyte memory size. Peripherals that could be added include more serial ports, an ethernet adapter, or USB circuitry.
Table 1 Host Communication Expansion Connector
A (CO106) PIN NAME VCC3_3 VCC[5] SDATA[31] SDATA[29] SDATA[27] SDATA[25] SDATA[23] SDATA[21] SDATA[19] SDATA[17] SDATA[15] SDATA[13] SDATA[11] SDATA[9] SDATA[7] SDATA[5] SDATA[3] SDATA[1] GND N/C WE/AT[0] WE/AT[2] N/C TSIZ1 N/C PORESET N/C TP109 TP111 GND 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 35 37 39 41 43 45 47 49 51 53 55 57 59
* * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * *
B (CO107) 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34 36 38 40 42 44 46 48 50 52 54 56 58 60 PIN NAME VCC3_3 VCC[5] SDATA[30] SDATA[28] SDATA[26] SDATA[24] SDATA[22] SDATA[20] SDATA[18] SDATA[16] SDATA[14] SDATA[12] SDATA[10] SDATA[8] SDATA[6] SDATA[4] SDATA[2] SDATA[0] GND N/C WE/AT[1] WE/AT[3] N/C TSIZ0 N/C SRESET TP108 TP110 TP112/DIS1 GND PIN NAME VCC3_3 VSTBY3_3 SADDR[31] SADDR[29] SADDR[27] SADDR[25] SADDR[23] SADDR[21] SADDR[19] SADDR[17] SADDR[15] SADDR[13] SADDR[11] SADDR[9] GND N/C CS[0] CS[2] OE N/C BURST TP113 TA TS TP114 BB/VF[2]/IWP[3] BG/VF[0]/LWP[1] CLKOUT TP116 GND 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 35 37 39 41 43 45 47 49 51 53 55 57 59
* * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * *
2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34 36 38 40 42 44 46 48 50 52 54 56 58 60
PIN NAME VCC3_3 VCC5 SADDR30 SADDR28 SADDR26 SADDR24 SADDR22 SADDR20 SADDR18 SADDR16 SADDR14 SADDR12 SADDR10 SADDR8 GND CSHCE CS1 CS3 RD/WE N/C BDIP N/C TEA BI/STS N/C BR/VF[1]/IWP[2] FRZ/PTR TP115 TP117 GND
Freescale Semiconductor, Inc...
NOTES: 1. EVB555 boards (revision 1.1/1.2) can be modified by connecting pin 58 (TP112) to pin 78 (DIS) of the TI Flash (IC400). This allows the TI Flash to be disabled and CS[0] to be useable by other devices. TP112 can then be pulled to ground through a 2K resistor. In addition, pin 6 of IC403 (/SGEOF) should be connected to pin 17 of RN303, a spare pullup resistor, to prevent the floating input of IC403. NOTE: these changes disable the external reset configuration word drivers on the EVB555 and may cause limitations with the ETAS ETK.
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 2
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
2.3 HCE Board Dimensions Figure 1 and Table 2 show the maximum board dimensions for boards designed to interface to the HCE connectors. Surface mount components should be used to keep the total height of the HCE board and connectors to 0.6875 inches (17.46 mm) to avoid interference with the optional ETAS ETK interface.
S
L
Host Communication Expansion
Freescale Semiconductor, Inc...
S
T
Figure 1 HCE Board Layout
Table 2 HCE Board Dimensions
Dimension L S T Millimeters 45.72 6.35 44.45 Inches 1.800 0.250 1.75
3 The Customized Communication Expansion Connectors (CCE)
The customized communication expansion connectors on the EVB555 allows access to the MPC555 on-chip communication ports. The EVB555 provides for RS-232 drivers and DB9 connector for the SCI1 channel of the MPC555. The CCE allows for customized connections to all of the MPC555 QSMCM and TouCAN interfaces. There are two 20-pin connectors (CO104 - A and CO105 - B) part number Samtec TFM-110-12-S-D-P. The matching connector required on the expansion board is SFM-110-02-S-D-P. The pin-out of the CCE is shown in Table 3. NOTE The TXD1 and RXD1 are, by default, connected to the on board RS-232 driver. These can optionally be brought to the TXD_CCE (7) and RXD_CCE (8) pins of connector CO105 by changing the position of the 0 resistors on BR100 and BR101 from position 1-2 to position 2-3.
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 3
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Table 3 Customized Communication Expansion Connector
A (CO104) PIN NAME VCC3_3 VCC5 N/C B_CNTX0 TP100 GND 1 3 5 7 9 11 13 15 17 19
* * * * * * * * * * * * * * * * * * * *
B (CO105) PIN NAME 2 4 6 8 10 12 14 16 18 20 VCC3_3 VCC5 CLKOUT B_CNRX0 TP101 GND A_CNRX0 TP103 PORESET GND PIN NAME VCC3_3 VCC5 N/C TXD_CCE ECK GND TP105 TXD2 TP107 GND 1 3 5 7 9 11 13 15 17 19
* * * * * * * * * * * * * * * * * * * *
PIN NAME 2 4 6 8 10 12 14 16 18 20 VCC3_3 VSTBY3_3 N/C RXD_CCE TP104 GND TP106 RXD2 TP118 GND
Freescale Semiconductor, Inc...
A_CNTX0 TP102 SRESET GND
3.1 CCE Board Dimensions Figure 2 and Table 4 show the maximum board dimensions for boards that attach the EVB555 CCE connector. NOTE Boards can extend off of the EVB for connectors. It is recommended that mounting hardware be supplied to attach the CCE board to the EVB.
M P N P
A
Customized Communication Expansion
B
R
U
Z (optional)
Figure 2 CCE Board Size
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 4
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Table 4 CCE Board Dimensions
Dimension M N U P R Z Millimeters 44.45 32.385 6.35 6.35 22.23 12.7 Inches 1.750 1.275 0.25 0.250 0.875 0.50
4 The MAPI-400+100 Connectors
Freescale Semiconductor, Inc...
The MAPI-400+100 is an extension of the Motorola MAPI-400 interface that is used on the Motorola M*Core products. An additional 100 pin connector was added to support the additional general purpose Input/Output pins from the Port Replacement Unit of the EVB555. NOTE Boards designed to interface to M*Core MAPI-400 boards may not work with the EVB555. Use of the MAPI-400 signals on the EVB555 is described in the ETAS EVB555 Quick Reference Guide.
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 5
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
4 x oM 99
J5(C0604)
Freescale Semiconductor, Inc...
J2(C0601)
1
2
1
J3(C0602)
2
J1(C0600)
TOP VIEW
MPC555 100 100 99 99
J4(C0603)
A
B
C
Figure 3 MAPI-400+100 Footprint
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
For More Information On This Product, Go to: www.freescale.com
2
1 L K J 2 2 1 H 1 G 0.0 PRIMARY DATUM F D 0.0 E
100
100
100
99 99
MOTOROLA 6
Freescale Semiconductor, Inc.
Table 5 MAPI-400+100 Dimensions
Dimension A B C D E F G Millimeters 91.45 83.82 45.72 7.62 14.22 31.78 10.16 58.42 104.14 111.76 127.00 3.20 Inches 3.60 3.300 1.800 0.300 0.560 1.250 0.400 2.300 4.100 4.400 5.000 0.126
Freescale Semiconductor, Inc...
H J K L M
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 7
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Table 6 MAPI-400 Signal Definitions
J1 (CO600) PIN NAME AAN[51]/PQB[7] AAN[52]/PQA[0] AAN[53]/PQA[1] AAN[54]/PQA[2] AAN[55]/PQA[3] AAN[56]/PQA[4] AAN[57]/PQA[5] AAN[58]/PQA[6] AAN[59]/PQA[7] PIN NAME 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 35 37 39 41 43 45 47 49 51 53 55 57 59 61 63 65 67 69 71 73 75 77 79 81 83 85 87 89 91 93 95 97 99 * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34 36 38 40 42 44 46 48 50 52 54 56 58 60 62 64 66 68 70 72 74 76 78 80 82 84 86 88 90 92 94 96 98 100 PIN NAME 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 35 37 39 41 43 45 47 49 51 53 55 57 59 61 63 65 67 69 71 73 75 77 79 81 83 85 87 89 91 93 95 97 99 * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34 36 38 40 42 44 46 48 50 52 54 56 58 60 62 64 66 68 70 72 74 76 78 80 82 84 86 88 90 92 94 96 98 100 J2 (CO601) PIN NAME AAN50_PQB6 AAN49_PQB5 AAN48_PQB4 AAN3_PQB3 AAN2_PQB2 AAN1_PQB1 AAN0_PQB0 Ground MDA12 MDA14 MDA27 MDA29 HRESETB EXTCLK BBB_IWP3 BGB_LWP1 BRB_IWP2 SGP_IRQOUTB EPEE Ground ENGCLK/BUCLK TXD1_QGPO TXD2_QGPO
Ground MDA11 MDA13 MDA15 MDA28 ETRIG1 ETRIG2 BDIP BIB_STSB BURSTB TSB Ground ECK RXD1_QGPI RXD2_QGPI
Freescale Semiconductor, Inc...
A_TPUCH[0] A_TPUCH[1] A_TPUCH[2] A_TPUCH[3] A_TPUCH[4] A_TPUCH[5] A_TPUCH[6] Ground A_TPUCH[7] A_TPUCH[8] A_TPUCH[9] A_TPUCH[10] A_TPUCH[11] A_TPUCH[12] A_TPUCH[13] A_TPUCH[14] IRQ[1]/SGP IRQ[3]/SGP IRQ[5]/SGP IRQ[7]/mck3 Ground
Ground MPWM[0] MPWM[1] MPWM[2] MPWM[3] MPWM[16] MPWM[17] Ground MPWM[18] MPWM[19] A_TPUCH[15] A_T2CLK
IRQ[0]/SGP IRQ[2]/SGP IRQ[4]/SGP IRQ[6]/mck2
Ground
MDA30 Ground MDA31 MPIO6 MPIO8 MPIO10 MPIO12 MPIO14
Ground MPIO5 MPIO7 MPIO9 MPIO11 MPIO13 MPIO15
Ground
Ground BAN0_PQB0 BAN1_PQB1 BAN2_PQB2 BAN3_PQB3 BAN48_PQB4 BAN49_PQB5 BAN50_PQB6
Ground
Ground
VPP
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 8
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Table 7 MAPI-400 Signal Definitions
J3 (CO602) PIN NAME
1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 35 37 39 41 43 45 47 49 51 53 55 57 59 61 63 65 67 69 71 73 75 77 79 81 83 85 87 89 91 93 95 97 99 * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34 36 38 40 42 44 46 48 50 52 54 56 58 60 62 64 66 68 70 72 74 76 78 80 82 84 86 88 90 92 94 96 98 100
J4 (CO603) PIN NAME
BAN51_PQB7 BAN52_PQA0 BAN53_PQA1 BAN54_PQA2 BAN55_PQA3 BAN56_PQA4 BAN57_PQA5 BAN58_PQA6 BAN59_PQA7
PIN NAME
Data_SGP1 Data_SGP3 Data_SGP5 Data_SGP7 Data_SGP9 Data_SGP11 Ground Data_SGP13 Data_SGP15 Data_SGP17 Data_SGP19 Data_SGP21 Ground Data_SGP23 Data_SGP25 Data_SGP27 Data_SGP29 Data_SGP31 Ground 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 35 37 39 41 43 45 47 49 51 53 55 57 59 61 63 65 67 69 71 73 75 77 79 81 83 85 87 89 91 93 95 97 99 * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34 36 38 40 42 44 46 48 50 52 54 56 58 60 62 64 66 68 70 72 74 76 78 80 82 84 86 88 90 92 94 96 98 100
PIN NAME
Data_SGP0 Data_SGP2 Data_SGP4 Data_SGP6 Data_SGP8 Data_SGP10 Ground Data_SGP12 Data_SGP14 Data_SGP16 Data_SGP18 Data_SGP20 Ground Data_SGP22 Data_SGP24 Data_SGP26 Data_SGP28 Data_SGP30 Ground
Freescale Semiconductor, Inc...
Ground A_CNRX0 A_CNTX0 B_CNRX0 B_CNTX0 SCK_QGP6 MISO_QGP4 Ground MOSI_QGP5 PCS0_QGP PCS1QGP PCS2QGP PCS3QGP
B_TPUCH0 B_TPUCH1 B_TPUCH2 B_TPUCH3 B_TPUCH4 B_TPUCH5 B_TPUCH6 B_TPUCH7 B_TPUCH8 B_TPUCH9 B_TPUCH10 B_TPUCH11 B_TPUCH12 B_TPUCH13 B_TPUCH14 B_TPUCH15 B_T2CLK VF0_MPIO0 VF1_MPIO1 VF2_MPIO2 Ground
Ground VFLS0_MPIO3 VFLS1_MPIO4 IWP0_VFLS IWP1_VFLS PORESETB Ground TMS TCK_DSCK TRST_B SRESET Ground Ground Ground
ADDR_SGP9 ADDR_SGP11 ADDR_SGP13 ADDR_SGP15 Ground ADDR_SGP17 ADDR_SGP19 ADDR_SGP21 ADDR_SGP23 ADDR_SGP25 ADDR_SGP27 ADDR_SGP29 ADDR_SGP31 Ground TAB RD_WRB Ground CS0B CS1B CS2B CS3B Ground CLKOUT Ground
TDO_DSDO TDI_DSDI TSIZ0 TSIZ1 RSTCONF/TEXP FRZ_PTR
ADDR_SGP8 ADDR_SGP10 ADDR_SGP12 ADDR_SGP14 Ground ADDR_SGP16 ADDR_SGP18 ADDR_SGP20 ADDR_SGP22 ADDR_SGP24 ADDR_SGP26 ADDR_SGP28 ADDR_SGP30 Ground TEAB WEB_AT[0] WEB_AT[1] WEB_AT[2] WEB_AT[3] OEB
Ground
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 9
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Table 8 MAPI-400 +100 PRU Extended Signal Definitions
J5 (CO605) PIN NAME B_PIO0 B_PIO1 B_PIO2 B_PIO3 B_PIO4 B_PIO5 B_PIO6 Ground B_PIO7 B_PIO8 B_PIO9 B_PIO10 B_PIO11 Ground B_PIO12 B_PIO13 B_PIO14 B_PIO15 B_PIO16 Ground B_PIO17 B_PIO18 B_PIO19 B_PIO20 B_PIO21 B_PIO22 B_PIO23 B_PIO24 Ground B_PIO25 B_PIO26 B_PIO27 B_PIO28 B_PIO29 B_PIO30 B_PIO31 Ground 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 35 37 39 41 43 45 47 49 51 53 55 57 59 61 63 65 67 69 71 73 75 77 79 81 83 85 87 89 91 93 95 97 99 * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34 36 38 40 42 44 46 48 50 52 54 56 58 60 62 64 66 68 70 72 74 76 78 80 82 84 86 88 90 92 94 96 98 100 PIN NAME A_PIO0 A_PIO1 A_PIO2 A_PIO3 A_PIO4 A_PIO5 A_PIO6 Ground A_PIO7 A_PIO8 A_PIO9 A_PIO10 A_PIO11 Ground A_PIO12 A_PIO13 A_PIO14 A_PIO15 A_PIO16 Ground A_PIO17 A_PIO18 A_PIO19 A_PIO20 A_PIO21 A_PIO22 A_PIO23 A_PIO24 Ground A_PIO25 A_PIO26 A_PIO27 A_PIO28 A_PIO29 A_PIO30 A_PIO31 Ground
Freescale Semiconductor, Inc...
Ground /EXTBUS Ground Ground Ground UB2 UB2 UB2
STANDBY Ground Ground Ground UB2 UB2 UB2
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 10
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
5 Lauterbach Trace Connector
The MPC555EVB includes a 64-pin connector to allow trace tools, such as Lauterbach's Trace-32, a simple connection to the signals required for trace.
Table 9 Lauterbach Universal MPC500/800 Family Trace Adapter Connector
CO500 PIN NAME ADDR20 ADDR11 ADDR19 ADDR18 ADDR17 DATA11 RD_WR DATA8 VCC3_3 DATA3 DATA2 DATA1 DATA0 VCC5 WE_AT0 GND CLKOUT WE_AT1 DATA7 DATA6 DATA5 GND DATA4 ADDR26 ADDR29 ADDR30 ADDR27 ADDR31 ADDR28 ADDR25 RSTCONF HRESET 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 35 37 39 41 43 45 47 49 51 53 55 57 59 61 63
* * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * *
2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34 36 38 40 42 44 46 48 50 52 54 56 58 60 62 64
PIN NAME ADDR21 ADDR22 ADDR23 ADDR24 ADDR12 ADDR13 ADDR14 ADDR15 ADDR16 WE_AT2 IRQOUT_LWP0 WE_AT3 BR_VF1_IWP2 DATA10 DATA9 IWP0_VFLS0 IWP1_VFLS1 BG_VF0_LWP1 BB_VF2_LWP3 ADDR10 ADDR9 ADDR8 BI_STS TS FRZ_PTR VFLS0_MPIO3 VFLS1_MPIO4 VF1_MPIO1 VF0_MPIO0 VF2_MPIO2 IRQ3_KR IRQ4_AT2
Freescale Semiconductor, Inc...
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 11
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
6 Mounting Holes
Figure 4 shows the mounting holes available to mount the EVB555 to other boards. Table 10 shows the dimensions of the connectors on the top side of the board.
U J B H Communication Expansion A B Customized
M N
Freescale Semiconductor, Inc...
A
Host Communication Expansion
TOP VIEW
L
MPC555
Y W
G
8 x K
F
0.0 AB C D E 0.0
Figure 4 Mounting Holes and Top-Side Connector Dimensions
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 12
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Table 10 Top Dimensions
Dimension A B C D E F G H J K Millimeters 120.00 115.19 79.63 39.63 4.70 13.34 29.22 182.89 200.00 2.80 45.72 44.45 32.385 6.35 32.39 66.675 Inches 4.724 4.535 3.135 1.560 0.185 0.525 1.150 7.200 7.874 0.110 1.800 1.750 1.275 0.250 1.275 2.625
Freescale Semiconductor, Inc...
L M N U W Y
7 Keep-Out Areas
All of the connectors on the top side of the EVB555 have keep-out areas associated with them to accommodate any board that could be connected to the expansion connectors. Figure 5 shows the various keep-out areas.
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 13
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Freescale Semiconductor, Inc...
ETK Keep-Out Area HCE, CCE, Lauterbach Keep-out Areas
Figure 5 Expansion Board Keep-Out Areas
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 14
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
8 Summary of Connectors
Table 11 shows the number and types of each kind of user extension connectors on the EVB555. Shown are the part numbers for the connectors on the EVB555 and the part numbers for connectors that are required for a user board.
Table 11 Summary Of Connectors
Connector CO100 Background Debug Mode Interface Number of Connectors on Board 1 each EVB555 Connector Part Number 3M 925320-01-10-10 Samtec TFM-110-12-S-D-P Samtec TFM-130-12-S-D-P AMP 767 004 product code 2429 3M 925320-01-20-10 Samtec FTE-132-02-G-DV-P Robinson Nugent P50L-100 S-BS-TGF 3M 8520-4500 (board mount) Samtec CLE-132-01-G-DV-P Robinson Nugent P50L-100 P-AS-TGF 3M CHG-2020-J01010-KCP (wire mount) User Board Connector Part Number (Surface Mount) 3M 8510-4500 JL (board mount) Samtec SFM-110-02-S-D-P Samtec SFM-130-02-S-D-P User Board Connector Part Number (Through Hole) 3M CHG-2010-J01010-KCP (wire mount)
Freescale Semiconductor, Inc...
CO104/CO105 Customized Communication Expansion CO106/CO107 Host Communication Expansion CO500-505 Mictor Digital Logic Analyzer CO506/CO507 Analog Logic Analyzer CO509 Lauterbach Interface CO600-604 MAPI-400+100
2 each
2 each
6 each
2 each 1 each 5 each
9 Reference
For more information see the following reference material. 9.1 MPC555 User's Manual The MPC555 User's Manual (MPC555UM/AD) is available from Motorola and describes the MPC555 device. The URL for the Motorola website is http://www.mcu.motsps.com/lit/mpc.html. 9.2 EVB555 MPC555 Evaluation Board Quick Reference, ETAS 9.3 SAMTEC Connectors Samtec has board layout recommendations and specifications for all of their connectors available online. The URL for this website is http://www.samtec.com. 9.4 Robinson Nugent Connector Further information on the Robinson Nugent connectors is available on-line. The URL for this website is http://www.robinsonnugent.com. At that site, search for P50L connectors.
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 15
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
9.5 Lauterbach More information on the Lauterbach real-time trace module is available on-line. The URL for this website is http://www.lauterbach.de.
10 Revision History
Table 12 Revision History
Release Number 1 Date Author Randy Dees Sections Affected Summary of Changes
31 July 01
Table 5
Added dimension A to Table 5. Renamed dimension I in Table 5 to agree with Figure 3.
Freescale Semiconductor, Inc...
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 16
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Freescale Semiconductor, Inc...
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 17
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Freescale Semiconductor, Inc...
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 18
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Freescale Semiconductor, Inc...
Designing Expansion Boards for the Motorola MPC555EVB/ETAS ES2000 Rev. 1, 31 July 2001
MOTOROLA 19
For More Information On This Product, Go to: www.freescale.com
Freescale Semiconductor, Inc.
Freescale Semiconductor, Inc...
Motorola reserves the right to make changes without further notice to any products herein. Motorola makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does Motorola assume any liability arising out of the application or use of any product or circuit, and specifically disclaims any and all liability, including without limitation consequential or incidental damages. "Typical" parameters can and do vary in different applications. All operating parameters, including "Typicals" must be validated for each customer application by customer's technical experts. Motorola does not convey any license under its patent rights nor the rights of others. Motorola products are not designed, intended, or authorized for use as components in systems intended for surgical implant into the body, or other applications intended to support or sustain life, or for any other application in which the failure of the Motorola product could create a situation where personal injury or death may occur. Should Buyer purchase or use Motorola products for any such unintended or unauthorized application, Buyer shall indemnify and hold Motorola and its officers, employees, subsidiaries, affiliates, and distributors harmless against all claims, costs, damages, and expenses, and reasonable attorney fees arising out of, directly or indirectly, any claim of personal injury or death associated with such unintended or unauthorized use, even if such claim alleges that Motorola was negligent regarding the design or manufacture of the part. Motorola is a registered trademark of Motorola, Inc. Motorola, Inc. is an Equal Opportunity/Affirmative Action Employer.
To obtain additional product information: USA/EUROPE: JAPAN: HONG KONG: MFAX: INTERNET: http://www.mot.com
Motorola Literature Distribution; P.O. Box 20912; Phoenix, Arizona 85036. 1-800-441-2447 Nippon Motorola Ltd.; Tatsumi-SPD-JLDC, Toshikatsu Otsuki, 6F Seibu-Butsuryu-Center, 3-14-2 Tatsumi Koto-Ku, Tokyo 135, Japan. 03-3521-8315 Motorola Semiconductors H.K. Ltd.; 8B Tai Ping Industrial Park, 51 Ting Kok Road, Tai Po, N.T., Hong Kong. 852-26629298 RMFAX0@email.sps.mot.com - TOUCHTONE (602) 244-6609
AN2001
For More Information On This Product, Go to: www.freescale.com

▲Up To Search▲

Price & Availability of AN2001

	To Download AN2001 Datasheet File
If you can't view the Datasheet, Please click here to try to view without PDF Reader .